Siemens ME45 Service Manual

Local Service Organization Service ManualBE INSPIREDS 4 5 / M E 4 5S 4 5 / M E 4 5iVersion 1.0

General InformationDue to different requirements of the markets, the S45/ME45 has different variants, which broadly classified under International ver

S45 Exploded Diagram Upper Case Shell S45 Silver L36158-A56-A1 Dark Blue L36158-A56-A2 Cushion (Display) S45 L36158-A56-C32 Keypad S45 Silver L36158-

FIGURE 2 S45 EXPLODED DIAGRAM.ME45 Exploded DiagramUpper Case Shell ME45Grey-BeigeL36158-A55-A11Grey-BlackL36158-A55-A7Cushion (Display) ME45L36158-

Figure 2.1 ME45 EXPLODED DIAGRAMPlease take note that the number(s) used here IS NOT the part number, DO NOT used it in your spare parts purchase ord

The displays will be shipped as complete modules from the suppliers. The design consists of the LCD-cell with a Tape Chip Carrier foil (TCP) and the l

Power Supply and Integrated ChargingOverview of HW StructureAll the important functions for the power supply of the phone are carried out by the suppl

For controlling the charging process it is necessary to measure the ambient (phone) temperature and the battery voltage. The temperature sensor will b

voltage collapses so much that the mobile phone switches off again. In this case trickle charging starts again with a now raised threshhold voltage of

Deep Discharge In case of a deeply discharged battery, the phone can not be turned on and the normal charging process can not be started.In this case

S I E M E N S C O M M U N I C A T I O N S L I M I T E DTable of ContentsC H A P T E R 1GPRS (General Packet Radio Services) 1Subscriber Identity

Dis-assembling the S45/ME45 A case opener is needed to disengage the latch of the S45/ME45 casing. This case opener is exactly the same as the P35 Se

Photo 2.4. Battery compartment Photo 2.5 Battery RemovingRemove the Battery from the right handside for the compartment as shown in PHOTO 2.5.Photo 2.

Photo 2.8 Lower case removngRemove the lower casing as shown in PHOTO 2.8STEP 5:Photo 2.9 RF board removingRemove the RF board from the upper casing a

STEP 6:Photo 2.10 Keypad PCB and Shield removingRemove the Keypad PCB from the Upper casing and the shielding from the RF Board as illustrated in

STEP 8Photo 2.12Removing of LCD latches Photo 2..13Disengage the flex cable connectorUsing a little force and remove the latch to unlock the LCD from

Photo 2.15 Upper case inner viewThe above PHOTO 2.14 and 2.15 illustrates the inner view components attached on the casings.Assembling S45/ME45STEP 1:

STEP 2:Photo 2.17 LCD latchesFasten the display to the RF board and by snapping the side latches as shown in PHOTO 2.17.In order to position the displ

STEP4:Photo 2.20 Keypad and Display cushion assemblyFirst, place the Display cushion on the uppercase and followed by the keypad. Next place the keypa

STEP 6:Photo 2.23 Top assembly Photo 2.24 Bottom assemblySecure the upper and the lowercase shell by snapping the upper part (PHOTO 2.23) and next the

STEP 8:Photo 2.27 Battery placement Photo 2.28 Battery compartmentInsert the battery by sliding it sideway first (PHOTO 2.27) and secure th

GPRS (General Packet Radio Services)Overview.PRS is a new non-voice value added services that allows information to be sent and received across a GSM

YesThe mobile equipment is uniquely identified by the International Mobile Equipment Identity, IMEI, which consists of 15 digits. Type approval grante

NoFLOWCHART 2.1 SOFTWARE PROGRAMMING. PROCESSYesNoYesNoPower up Boot Adaptor &Check LEDError ?Error ?Ok ?Ok ?Ok ?

Language GroupsThere are over 20 languages for the S45/ME45 in total. These languages are divided into groups as followsLanguage groups K45 Lang

When the phone is disable due to wrong entry of PHONECODE, it can be re-activated by entering the right unblocking code. This unblocking code is d

1. Internet SolutionA password protected homepage where LSO can enter IMEI number of a disable phone. The generated Master Code will then be presented

ANNEX AEXPLOSION VIEW DIAGRAM – ACCESSORIES

Subscriber Identity Module(SIM)SIM is a smart card which has a computer and memory chip that is permanently installed in the mobile equipment. It come

Level 2 Service GuideIntroductionThis chapter serves as a guideline to help the respective service personnel in the repairing of S45/ME45 mobile phone

S45/ME45 Technical InformationFeaturesSystem/Standards D U A L B A N D E G S M 9 0 0 / G S M 1 8 0 0G S M P H A S E 2 / P H A S E

Dictaphone Exciting gamesAvailable colour variants: Sapphire Blue, Diamond Silver (vary country by country)High speed data transfer, speedy internet a

• 850 mAh Li-Ion battery (standard) L36880-N4501-A100• Car cradle standard L36880-N4501-A102• Car cradle with antenna cap L36880-N4501-A103• Belt Clip

 Charger Battery Cover Battery (no laser label) Accessory leaflet User Manual  Mini CD-ROM Data cableMini CD-ROM (capacity 129MB) contai